|This article needs additional citations for verification. (July 2008)|
Straw is an agricultural by-product, the dry stalks of cereal plants, after the grain and chaff have been removed. Straw makes up about half of the yield of cereal crops such as barley, oats, rice, rye and wheat. It has many uses, including fuel, livestock bedding and fodder, thatching and basket-making. It is usually gathered and stored in a straw bale, which is a bundle of straw tightly bound with twine or wire. Bales may be square, rectangular, or round, depending on the type of baler used.
Current and historic uses of straw include:
- Animal feed
- Straw may be fed as part of the roughage component of the diet to cattle or horses that are on a near maintenance level of energy requirement. It has a low digestible energy and nutrient content. The heat generated when microorganisms in a herbivore's gut digest straw can be useful in maintaining body temperature in cold climates. Due to the risk of impaction and its poor nutrient profile, it should always be restricted to part of the diet. It may be fed as it is, or chopped into short lengths, known as chaff.
- Bee skeps and linen baskets are made from coiled and bound together continuous lengths of straw. The technique is known as lip work.
- Bedding: humans or livestock
- The straw-filled mattress, also known as palliasse, is still used in many parts of the world.
- It is commonly used as bedding for ruminants and horses. It may be used as bedding and food for small animals, but this often leads to injuries to mouth, nose and eyes as straw is quite sharp.
- The use of straw as a carbon-neutral energy source is increasing rapidly, especially for biobutanol. Straw or hay briquettes are a biofuel substitute to coal.
- The use of straw in large-scale biomass power plants is becoming mainstream in the EU, with several facilities already online. The straw is either used directly in the form of bales, or densified into pellets which allows for the feedstock to be transported over longer distances. Finally, torrefaction of straw with pelletisation is gaining attention, because it increases the energy density of the resource, making it possible to transport it still further. This processing step also makes storage much easier, because torrefied straw pellets are hydrophobic. Torrefied straw in the form of pellets can be directly co-fired with coal or natural gas at very high rates and make use of the processing infrastructures at existing coal and gas plants. Because the torrefied straw pellets have superior structural, chemical and combustion properties to coal, they can replace all coal and turn a coal plant into an entirely biomass-fed power station. First generation pellets are limited to a co-firing rate of 15% in modern IGCC plants.
- Construction material:
- In many parts of the world, straw is used to bind clay and concrete. A mixture of clay and straw, known as cob, can be used as a building material. There are many recipes for making cob.
- When baled, straw has moderate insulation characteristics (about R-1.5/inch according to Oak Ridge National Lab and Forest Product Lab testing). It can be used, alone or in a post-and-beam construction, to build straw bale houses. When bales are used to build or insulate buildings, the straw bales are commonly finished with earthen plaster. The plastered walls provide some thermal mass, compressive and ductile structural strength, and acceptable fire resistance as well as thermal resistance (insulation), somewhat in excess of North American building code. Straw is an abundant agricultural waste product, and requires little energy to bale and transport for construction. For these reasons, strawbale construction is gaining popularity as part of passive solar and other renewable energy projects.
- Composite lumber Wheat straw can be used as a polymer filler combined with polymers to produce composite lumber.
- Enviroboard can be made from straw.
- Erosion control
- Straw bales are sometimes used for sediment control at construction sites. However, bales are often ineffective in protecting water quality and are maintenance-intensive. For these reasons the U.S. Environmental Protection Agency (EPA) and various state agencies recommend use of alternative sediment control practices where possible, such as silt fences, fiber rolls and geotextiles.
- Burned area emergency response
- Ground cover
- In-stream check dams
- There are several styles of straw hats that are made of woven straw.
- Many thousands of women and children in England (primarily in the Luton district of Bedfordshire), and large numbers in the United States (mostly Massachusetts), were employed in plaiting straw for making hats. By the late 19th century, vast quantities of plaits were being imported to England from Canton in China, and in the United States most of the straw plait was imported.
- A fiber analogous to straw is obtained from the plant Carludovica palmata, and is used to make Panama hats.
- Straw is used in cucumber houses and for mushroom growing.
- In Japan, certain trees are wrapped with straw to protect them from the effects of a hard winter as well as to use them as a trap for parasite insects.
- It is also used in ponds to reduce algae by changing the nutrient ratios in the water.
- The soil under strawberries is covered with straw to protect the ripe berries from dirt, and straw is also used to cover the plants during winter to prevent the cold from killing them.
- Straw also makes an excellent mulch.
- Straw is resistant to being crushed and therefore makes a good packing material. A company in France makes a straw mat sealed in thin plastic sheets.
- Straw envelopes for wine bottles have become rarer, but are still to be found at some wine merchants.
- Wheat straw is also used in compostable food packaging such as compostable plates. Packaging made from wheat straw can be certified compostable and will biodegrade in a commercial composting environment.
- Straw can be pulped to make paper.
- Rope made from straw was used by thatchers, in the packaging industry and even in iron foundries.
- Heavy gauge straw rope is coiled and sewn tightly together to make archery targets. This is no longer done entirely by hand, but is partially mechanised. Sometimes a paper or plastic target is set up in front of straw bales, which serve to support the target and provide a safe backdrop.
- *The Straw Bale House: Suitability for the Eastern U.S.
- Adding Value to Wheat Straw By Anduin Kirkbride-McElroy. Biomass Magazine, 2007
- California Stormwater Quality Association. Menlo Park, CA. “California Stormwater BMP Handbook: Straw Bale Barrier.” Best Management Practice (BMP) No. SE-9. January 2003.
- U.S. Environmental Protection Agency. Washington, DC. "National Menu of Stormwater Best Management Practices: Straw or Hay Bales." June 1, 2006.
- Baynes, T.S.; Smith, W.R., eds. (1887). "Straw Manufactures". Encyclopaedia Britannica 22 (9th ed.).
- "Straw". The American Cyclopædia. 1879.
- Viv Biz Club: Compostable Plates
|Wikimedia Commons has media related to Straw.|
|Wikimedia Commons has media related to Straw bales.|
- Chisholm, Hugh, ed. (1911). "Straw and Straw Manufactures". Encyclopædia Britannica (11th ed.). Cambridge University Press